Your house-water sources

Showering with rain water is double the fun!

Create potable water easily and economically with new water treatment technology.

The idea of a self-sustaining water supply is not novel. In most cases, you will find these self-sustaining water supply systems in rural, undeveloped regions, which are catered groundwater. Unfortunately, every home owner does not have the same opportunity to take advantage of such sources. Rainwater however, is available almost everywhere, but to date, it has hardly been used for any other purposes except for flushing toilets and watering the garden.

According to the European drinking water regulations, the water used for body hygiene, such as showering and washing hands, must be of potable water quality.

In order to fulfil the requirements of the EC Directive "water for human consumption," INTEWA GmbH has now employed a special new concept, by creating a prototype system for the single family dwelling, within the framework of the EU project "Eco Innovation" water for reuse within the home.

Since in this project sufficient rainwater is not available for all consumers, the new system utilises shower water (called grey water) after it has been collected and treated and then used again for toilet flushing. At the same time, the heat apparent in the shower water is extracted from the grey water and utilised in pre-heating the shower water again.

 

Precious rainwater

The main advantages of AQUALOOP Technology:

  • saving of potable water  resources
  • saving of additional infrastructure like canals and supply systems
  • cost saving for both water provider and consumer
  • more freedom from dependence on the water provider
  • soft, calcium-free water  
  • no anthropogenic micro pollutants in the water
  • easy retrofitting by using the existing house water pipework

 

Retrofitting the AQUALOOP Rainwater system

The rainwater is collected from 120 m² large roof surface and collected in a 10 m³ cistern.

The self-cleaning PURAIN rainwater filter (with built-in skimmer overflow, backflow valve and hydraulic jump principle) cleanses the water using a 0.8 mm stainless steel wedge wire filter. The rainwater is micro-filtered (sterilised) by the AQUALOOP membrane station situated inside the tank using membrane fibres with a pore size of 0.2 µm, and then fed into a 350 litre clear water storage tank situated in the basement. In order to exclude - possible - potential microbial contamination later in the basement tank, the water is additionally disinfected prior to distribution within the dwelling with UV treatment.

Retrofitting the rainwater cistern by the construction company Lemmens, Gemmenich

This purified water is pumped using the speed-controlled water supply unit RAINMASTER Favorit SC, into the existing water line and provided to all the consumers in the house. The municipal water supply system is connected only to the DVGW certified RAINMASTER Favorit and to the drinking water supply in the kitchen. The water quality produced by the AQUALOOP system is checked at regular intervals. If the results of ongoing testing prove a consistently high level of treatment then the drinking water supply in the kitchen could also be supplied with rainwater from the Aqualoop system in the future, too.

Since the existing house water supply pipes can be fully utilised, this concept allows easy retrofitting of rainwater systems for the first time.

Overview of AQUALOOP rainwater system

  • Collecting rainwater from 120 m² roof area
  • PURAIN 100 rainwater filter incl. skimmer overflow and backflow valve, with inlet calming
  • Storage in a 10 m³ external tank
  • AQUALOOP Membrane station, combining ultra-filtration and micro-filtration membranes situated in the tank
  • 350 litre clean water tank situated in basement for sterilised water
  • Pumping from clean water tank throughout the house with RAINMASTER Favorit 20-SC
  • 20 Watt UV sterilisation for additional safety
  • increase of pressure in existing supply system
  • Connection to shower, washing machine, wash basin etc.
  • Additional water supply via RAINMASTER with municipal water, should treated water not be available
  • a separate municipal water supply for kitchen tap

Water quality of rainwater

The quality of rain water and the cleaning performance of the system have been investigated through the testing of the entire system at different points. The analysis results show that the bacterial load of the raw water from the rainwater tank is already very low. Neither the bacterium E. Coli, which is an important indication of contamination with faecal matter, nor the pathogen Pseudomonas Aeruginosa, were found in the tested samples.

 

Clean water storage tank with RAINMASTER Favorit SC, AQUALOOP controller, UV sterilization

The treatment potential of the Aqualoop membrane can be proven by the analysis of treated water after microfiltration, in which no coliform bacteria and bacterial colonies were detected. As per the result of analysis, the additional sterilisation by UV lamp is not actually necessary but it provides additional security. The limits of the drinking water regulations for "water for human consumption" are met for all examined parameters (See Table 1). Only the pH value was exceeded in the first sample.

Analyseergebnisse der AQUALOOP Regenwasseranlage

Parameter Grenzwert (nach TrinwV) Aufbereitung durch AQUALOOP
Escherichia Coli 0 /100ml 0 /100ml
Enterokokken 0 /100ml 0 /100ml
Coliforme Bakterien 0 /100ml 0 /100ml
Koloniezahl 22 °C 1000 /ml 0 /ml
Koloniezahl 36 °C 100 /ml 0 /ml
Pseudomonas Aeruginosa 0 /100ml  
TOC --- 0,85 mg/l
pH-Wert vor Ort 9,5 8,58
Calcium   9,9 mg/l
Magnesium   <0,5 mg/l
Leitfähigkeit bei 25°C 2790 μs/cm 64 μs/cm
Kupfer 2 mg/l <0,002 mg/l
Nickel <0,02 mg/l <0,005 mg/l
Trübung im Labor 1 NTU 0,11 NTU
Clostridium perfringens 0 /100ml 0 /100ml
Nitrat 50 mg/l 3,4 mg/l
Nitrit 0,5 mg/l <0,02 mg/l
Quecksilber <0,001 mg/l <0,0002 mg/l
Cadmium <0,001 mg/l <0,003 mg/l
     
Quelle: Institut für Wasser- und Abwasseranalytik GmbH    

AQUALOOP Grey water recycling

AQUALOOP Grey water recycling system incl. warm storage (The washing machine is connected to the rainwater network.)

In this demonstration project, the rain water alone is not enough to cover the entire water requirements for a family of four people. Therefore, a further 30 m³/year or so of water can be saved by the additional recycling of household grey water, obtained from shower and wash basin, and thereby the total household water requirement (100m³/year) can be covered.  The only lightly contaminated grey water, obtained from personal hygiene use, is purified in the AQUALOOP grey water recycling system and then used for toilet flushing within the home.
In contrast to the rainwater tank, the grey water system utilises two very small 350 litre storage tanks), which provide the approximate daily water requirement for toilet flushing. First of all, coarse contaminants, such as hair are separated by the AQUALOOP pre-filter. After this, the water is biologically treated in the aerated, fluidized tank by microorganisms that proliferate on the provided support media. The microfiltration stage draws water through the pores of the hollow fibre membrane, positioned in the AQUALOOP membrane station, removing all bacteria and viruses apparent in the grey water. The biologically treated and sterilized water then meets at minimum the EU bathing water quality guidelines. The rainwater unit RAINMASTER Eco supplies the treated water to toilets from the grey water systems clear water tank.

Analysis results of AQUALOOP Grey water system

Water Parameter NSF specifications Grey water
E. Coli 14/100ml < 1
Turbidity 5 NTU 0,5 NTU
pH 6-9 7,8
BSB5 10 mg/l 5 mg/l *
     
*8 weeks after starting phase    
Table 2: Analysis results of AQUALOOP Grey water system    
Source: PIA Prüfinstitut für Abwassertechnik GmbH    

Overview of AQUALOOP Grey water system

  • Aerated fluid bed bioreactor in 350 litre tank
  • AQUALOOP pre-filter incl. skimmer overflow, siphon overflow and backflow valve
  • AQUALOOP membrane station with ultra/micro filtration
  • Temporary storage in 350 litre clean water tank
  • clean water pumping to toilets with RAINMASTER-Eco (100 Watt power),  through separate water supply pipes to toilets
  • Supply of treated rainwater

Overview of AQUALOOP Rainwater and Grey water systems

1. Grey water tank 350 litre 8. Clear water tank for rainwater 350L
2. AQUALOOP Grey water membrane station 9. UV system
3. --- 10. Rainwater pump RAINMASTER-Favorit-SC
4. AQUALOOP Grey water pre-filter 11. Rainwater tank 10 m³
5. Clear water tank for grey water 350L 12. AQUALOOP rainwater membrane station
6. Grey water pump RAINMASTER-Eco 13. PURAIN 100 rainwater filter
7. Hot water storage tank  

Risks

The direct risk of transmission of pathogens by rain water is eliminated by the AQUALOOP system’s sterilization. Depending on the location of rainwater system, it has to be examined which parameters need to be checked in order to meet drinking water quality, including the dissolved chemical substances (dissolved solids). For instance, copper or zinc roofs can lead to increased input of these metals in collected water. In regions where the air  contains high levels of environmental contaminants, "acid rain" may occur. Due to low pH value, the risk of releasing metals from corrosion increases. The pH value should then be neutralized through simple measures. There is a risk of elutriation of heavy metals in regions with very poor air quality. The corresponding concentrations in rainwater must be checked in regions close to heavy industrial emissions or very high traffic. In most European countries, contamination of air has not been considered problematic for several years. Due to improved environmental protection measures the quality of rainwater is usually very good.

Costs and saving potential of this demonstration project

Considering the cost and saving potential of this technology, it should be noted that general information is hard to determine due to the different area water costs, charges and consumption. Nonetheless, suitable repayment periods, which are significantly less than the age of building can often be achieved with this new system technology. The self-sustaining water supply with rainwater can make sense in several areas:

Location Kelmis, Belgium
Roof collection area 120 m²
Rainwater yield approx. 90 m³ / year
Water consumption of 4 people* approx. 105 m³ / year
RW consumption approx. 70 m³ / year
GW consumption approx. 30 m³ / year
Saving potential approx. 100 m³ / year
Average cost of water in D** 5.00 €/ m³
Energy consumption cost of the system/m³ at 0.23€/kWh 0.43 €/m³
Saving potential DE after deducting energy consumption cost 4.57 €/m³
Model 1***: Rain water and grey water Total cost approx. 15,684.00 €
Statistical Amortisation 16.73 years
Model 2***: Only rainwater Total cost approx. 9621.15 €
Statistical Amortisation 12.03 years
Model 3***: Only rainwater
all work “do it yourself”
Total cost approx. 7241.15 €
Statistical Amortisation 9.05 years

*for comparison: Ø Water consumption of 4 persons in Germany is 180 m³
Ø Water consumption of 4 persons in USA is 430 m³
** Potable water and drainage costs, the drainage costs cannot be calculated while splitting fee
*** Ø Water consumption of 175 m³/year

Summary

With this EU funded demonstration project, it could be impressively demonstrated that it is possible to substitute almost the entire water consumption of a single family dwelling with rainwater by the help of the new AQUALOOP technology.

It is worth noting that this technology can be easily and economically retrofitted into an existing building. Thus, this technology is suitable for both new constructions as well as for current dwellings.
If sufficient rainwater is not available, then the gap can be filled by recycling accumulated grey water. In addition to this, the heat exchanger allows recovering heat from the warm grey water.

AQUALOOP technology may represent a new field of business in the future for companies belonging to the water treatment, rainwater harvesting sectors as well as for the manufacturers of water storage tanks.
Saving precious potable water reserves is an important contribution to the environment.

Author: Oliver Ringelstein, Manager INTEWA GmbH
Words:1.621

Images collection

Images_artikel_shower_with_Rainwater.zip

Archives for images

The possibility to save drinking water has enhanced strongly the last years.

» more

A rainwater filter cleaning itself by the principle of the hydraulic jump.

» more

The DRAINMAX tunnel infiltration system: The only plastic trench with flushable  ground.

» more

The optimized water pump station for rainwater and greywater utilization in every planned construction.

» more
 

Information

Tel. 001 (0) 404 824 9266

E-Mail: info@us.intewa.net

SitemapConditionsImprint

Co­py­right © 2013 • IN­TE­WA United States